1986 Chevy Truck C 10 P/U Steering Column: Service and Repair Assembly
download 1. To assemble bearing housing, proceed as follows: a. Using a suitable socket, press bearings into bearing housing. b. Install lock shoe springs, lock shoes and shoe pin into bearing housing....
View Article2000 Volkswagen Jetta Transmission, Disassembling And Assembling
download 1. 2. 3. 4. 5. 6. 1st gear 2nd gear 3rd gear 4th gear 5th gear Transmission housing Servicing. Refer to Case, M/T. 7. Selector mechanism (Selector forks) Disassembling and assembling. Refer to...
View Article2001 Dodge Ram 2500 BEARING NOISE Testing and Inspection
download GEAR NOISE Axle gear noise can be caused by insufficient lubricant, incorrect backlash, incorrect pinion depth, tooth contact, worn/damaged gears, or the carrier housing not having the proper...
View ArticleFord / Mercury / Lincoln Band-Mounted Sensor Re-Learn Instructions
The instructions below can be used for the following vehicles: 2008 Ford Crown Victoria / Lincoln Town Car / Mercury Grand Marquis 2008 Ford E-series 2007-2009 Ford Edge / Lincoln MKX 2005-2008 Ford...
View Article2007 TOYOTA TUNDRA SPORT SHIFT KNOB installation
download 1. Vehicle Preparation. (FJ Cruiser shown) (a) Vehicle must be on level ground and not on an incline/decline. (b) Fully engage the parking brake. (c) Remove the shift lock release cover. Save...
View Article1999 Ford F-Super Duty 250-550 Automatic Transaxle/ Transmission Cable and...
download 1. NOTE: To prevent cable damage, do not apply force to the transmission shift cable assembly between the steering column shift tube bracket and the steering column bracket. Disconnect the...
View Article2000 Jeep Wrangler SHIFT BOOT REMOVAL
download 1. Using a trim stick C-4755 or equivalent, pry the shift boot from the bezel. 2. Using a small flat blade, pry the shift pattern insert from the shift knob. 3. Remove the nut attaching the...
View Article2006 Pontiac GTO Transmission Jumps Out of Gear
download If the transmission jumps out of gear during deceleration, inspect the components that may allow for the gears or shafts to tip. If the gears or shafts tip, the synchronizer sleeve can...
View Article2008 Accord V6 with M/T 2-Door Transmission Grinds When Shifting Into 3rd Gear
download SYMPTOM The 6-speed manual transmission grinds when shifting into 3rd gear, pops out of 3rd gear, or is hard to shift into 3rd gear. NOTE: These symptoms can be intermittent and sometimes more...
View Article1993 Mitsubishi Montero TRANSFER CASE DISASSEMBLY
download Disassembly (Ram-50) 1) Remove both 4WD indicator switches and steel balls. Remove speedometer gear assembly. Remove output shaft cover, gasket, wave spring and spacer. See Fig. 3. Remove rear...
View Article2002-2004 Isuzu Axiom A/T – Shift Lock Solenoid Replacement
download TSB SB05-05-5004 Shift Lock Solenoid ISSUE DATE: MAY 2005 Affected Vehicles 2002-2004 Isuzu Axiom (UP) 1998-2004 Isuzu Rodeo (UE) and Rodeo Sport (UA) Service Information Use the following...
View Article
